Saint Petersburg Mining University, Saint Petersburg, Russia:

O. L. Lobacheva, Associate Professor at the Department of General Chemistry, Candidate of Chemical Sciences, e-mail: Olga-59@yandex.ru
N. V. Dzhevaga, Associate Professor at the Department of Geoecology, Candidate of Chemical Sciences
A. S. Danilov, Assistant Lecturer at the Department of Geoecology, Candidate of Technical Sciences

This paper describes the results of experimental and theoretical studies that looked at ion exchange processes in liquid phase systems containing nonferrous metals, rare earth elements and a surfactant — i.e. sodium dodecylsulphate (NaDS). Ion flotation processes are considered in reciprocal systems containing Co⁺² and Ni⁺². There is a number of reasons for choosing the above salts:
– The problem of removing cations of heavy metals (in particular, Co⁺² and Ni⁺²) from water is of relevance;
– At рН 7, these ions do not form hydroxides or hydroxide residue;
– Co⁺² and Ni⁺² bond with NaDS to form easily soluble salts;
– Quite a few low-cost analysis techniques are known that can detect these ions.
Ion flotation processes were also examined in systems containing rare earth elements, NaCl and surfactants. The influence of Cl^– ions on the distribution coefficient in Sm⁺³ and Eu⁺³ containing systems was studied by comparing instability constants typical of chlorine compounds and hydroxides. It was found that a rising concentration of NaCl is associated with a rising pH of cations of the rare earth elements of interest at the early stage of recovery and during the peak recovery. The paper considers an innovative technique to examine systems with rare earth elements and surfactants — i.e. solvent sublation. The authors examine the possibility of recovering ions of lanthanides (e.g. erbium) by solvent sublation using NaDS as a collector and isooctyl alcohol as an extractant. Many researchers believe the latter to be the best agent for such studies. The concentration of Er⁺³ in the standard test solutions was 0.001 mol/l. As the process develops, the concentration of extracted ions asymptotically approaches the value that is typical of a system approaching its steady state. It was established that in these conditions the maximum recovery for Er⁺³ is reached at рН of 8.0.

This research study was funded through a scholarship granted by the President of the Russian Federation to young researchers and postgraduate students under the following project: SP-347.2019.1 “Ion flotation as an innovative and efficient technique to recover rare earth elements while concentrating dilute industrial solutions with possible identification of elements”.

1. Matveeva V., Danilov A., Pashkevich M. Treatment of multi-tonnage manganese-containing waste water using vermiculite. Journal of Ecological Engineering. 2018. Vol. 19, Iss. 1. pp. 156–162. DOI: 10.12911/22998993/79416.
2. Strizhenok A. V., Korelskiy D. S., Kuznetsov V. S. The wastewater disposal system modernization during processing of amber deposit as a way to reduce the anthropogenic load on the baltic sea ecosystem. Journal of Ecological Engineering. 2019. Vol. 20, Iss. 3. pp. 30–35. DOI: 10.12911/22998993/99731.
3. Lutskiy D., Litvinova T., Ignatovich A., Fialkovskiy I. Complex processing of phosphogypsum — a way of recycling dumps with reception of commodity production of wide application. Journal of Ecological Engineering. 2018. Vol. 19, Iss. 2. pp. 221–225. DOI: 10.12911/22998993/83562.
4. Sebba F. Ion flotation. Moscow : Metallurgiya, 1965. 170 p.
5. Lemlich R. Adsorptive bubble separation techniques. N.Y. : Academic Press, 1972. 344 p.
6. Karger B. L., Devivo D. G. General survey of adsorptive bubble separation processes. Separation Science and Technology. 1968. Vol. 3, No. 5. pp. 393–424.
7. Abramov A. A. Concentration by flotation. Moscow : Nedra, 2008. 711 p.
8. Bazhin V. Y., Aleksandrova T. A., Kotova E. L., Suslov A. P. A modern view of anomalies in the metal groups of the periodic system of D. I. Mendeleev. Journal of Mining Institute. 2019. Vol. 239. pp. 520–527. DOI: 10.31897/PMI.2019.5.520.
9. Smirnova E., Lutskiy D. Improving the efficiency of purification in the technological cycles of limestone processing. ARPN Journal of Engineering and Applied Sciences. 2019. Vol. 14, Iss. 12. pp. 2306–2309.
10. Pashkevich M. A., Matveeva V. A., Danilov A. S. Migration of pollutants from the mining waste disposal territories on the Kola Peninsula. Gornyi Zhurnal. 2019. No. 1. pp. 17–21. DOI: 10.17580/gzh.2019.01.04.
11. Strizhenok A. V., Korelskiy D. S. Improvement of the system of industrial environmental monitoring of atmospheric air in the area of anthropogenic arrays impact. Journal of Physics: Conference Series. 2019. Vol. 1384. DOI: 10.1088/1742-6596/1384/1/012052.
12. Goman I. V. Case study analysis as a way of developing the environmental accountability of future oil and gas engineers. International Multidisciplinary Scientific GeoConference Surveying Geology and Mining Ecology Management, SGEM. 2017. Vol. 17, Iss. 54. pp. 17–26. DOI: 10.5593/sgem2017/54/S22.003.
13. Goman I. V., Varlakova E. A. Teaching communication skills in a foreign language to students of oil and gas specialization. Ibid. 2019. Vol. 19, Iss. 5.4. pp. 295–300. DOI: 10.5593/sgem2019/5.4/S22.040.
14. Goman I. V. Development of the dialogue skills in a foreign language in comparing of oil benchmarks. Journal of Physics: Conference Series. 2019. Vol. 1384, Iss. 1. DOI: 10.1088/1742-6596/1384/1/012013.
15. Chang L., Cao Y., Fan G., Li C., Peng W. A review of the applications of ion floatation: Wastewater treatment, mineral beneficiation and hydrometallurgy. RSC Advances. 2019. Vol. 9, Iss. 35. pp. 20226–20239. DOI: 10.1039/c9ra02905b.
16. Hoseinian F. S., Rezai B., Safari M., Deglon D. et al. Effect of hydrodynamic parameters on nickel removal rate from wastewater by ion flotation. Journal of Environmental Management. 2019. Vol. 244. pp. 408–414. DOI: 10.1016/j.jenvman.2019.05.067.
17. Ghosh R., Vaishampayan V., Mahapatra A., Malhotra R. et al. Enhancement of limit of detection by inducing coffee-ring effect in water quality monitoring microfluidic paper-based devices. Desalination and Water Treatment. 2019. Vol. 156. pp. 316–322. DOI: 10.5004/dwt.2019.23715.
18. Dzhevaga N. V., Lobacheva O. L. Analysis of the mixture of rare earth elements by atomic spectroscopy. Journal of Physics: Conference Series. 2019. Vol. 1384, Iss. 1. DOI: 10.1088/1742-6596/1384/1/012008.
19. Abramzon A. A. Surface active agents. Reference book. Leningrad : Knimiya, 1979. 376 p.
20. Rusanov A. I., Levichev S. A., Zharov V. T. Surface separation of substances. Leningrad : Knimiya, 1981. 184 p.
21. Lobacheva O., Dzhevaga N. Rare-earth elements recovery on the example of Europium (III) from lean technogenic raw materials. Journal of Ecological Engineering. 2017. Vol. 18, Iss. 6. pp. 122–126. DOI: 10.12911/22998993/76827.
22. Lobacheva O. L., Chirkst D. E., Dzhevaga N. V., Bazhin V. Yu. Ion flotation of cations of cerium group. Russian Journal of Applied Chemistry. 2013. Vol. 86, Iss. 12. pp. 1862–1866. DOI: 10.1134/S1070427213120100.
23. Savin S. B. Arsenazo III. Moscow : Atomizdat, 1966. 265 p.
24. Chirkst D. E., Lobacheva O. L., Berlinskii I. V., Dzhevaga N. V. Thermodynamics of formation of lanthanide hydroxo complexes in aqueous solutions. Russian Journal of Inorganic Chemistry. 2012. Vol. 57, No. 4. pp. 605–609.
25. Lu S., Zhu X. Solvent sublation: theory and application. Separation and Purification Methods. 2001. Vol. 30, No. 2. pp. 157–189.
26. Lobacheva O. L. Solvent sublation of nickel from diluted aqueous solutions. Zapiski Gornogo instituta. 2006. Vol. 169. pp. 156–158.
27. Lobacheva O. L., Berlinskii I. V., Cheremisina O. V. Solvent sublation and ion flotation in aqueous salt solutions containing Ce (III) and Y (III) in the presence of a surfactant. Russian Journal of Applied Chemistry. 2014. Vol. 87, No. 12. pp. 1863–1867.