Журналы →  CIS Iron and Steel Review →  2023 →  №1 →  Назад

Chemical technologies
Название Increase of efficiency of electroflotation extraction of low-soluble manganese compounds from water solutions in presence of flocculants of anion, cation and non-ion types
DOI 10.17580/cisisr.2023.01.18
Автор V. A. Brodskiy, D. Yu. Zhukov, Yu. O. Malkova
Информация об авторе

Mendeleev University of Chemical Technology of Russia (Moscow, Russia):

V. A. Brodskiy, Cand. Chem., Senior Researcher, e-mail: vladimir_brodsky@mail.ru
D. Yu. Zhukov, Cand. Eng., Director of Technological Center “Ekokhimproekt”, e-mail: Zhukov.d.i@muctr.ru
Yu. O. Malkova, Leading Engineer, e-mail: jui77_77@mail.ru


The process of electroflotation extraction of dispersed phase of manganese (II-IV) low-soluble compounds from water solutions with different ion composition is examined. The process of forming of dispersed phase in presence of OН-, CO32-, PO43- ions, as well as flocculants of anion, cation and non-ion types is studied. It was shown that efficiency of electroflotation process depends directly on dispersity and electrokinetic potential of particles, which are determined by acidity and ion composition of the medium. Maximal average hydrodynamic diameter of dispersed phase of low-soluble manganese compounds were observed in the pH area 10-11, what corresponded to minimal solubility of dispersed phase. In this case the process of electroflotation extraction passed with maximal efficiency, extraction degree achieved 96 %. Introduction of cation flocculant in solutions allowed to rise extraction degree up to 98 %. Addition of CO32- and PO43- ions in solutions caused shift of ζ-potential of dispersed phase in the area of negative values (-18 mV and -33 mV respectively), what finalized in complication of forming of flotation complexes “particle - Н2, О2 bubbles” and to complication of coagulation processes. Extraction degree did not exceed 10 % in both cases. Addition of cation and non-ion flocculants in the examined solutions allowed to compensate negative charge of dispersed phase, to enlarge this phase and to rise extraction degree of manganese (II) low-soluble compounds to 98 %.

The research was carried out under financial support of Mendeleev University of Chemical Technology of Russia within the framework of VIG-2022-073.
Authors express their gratitude to the D. I. Mendeleev Center for the collective use of scientific equipment for assistance in carrying out the research.

Ключевые слова Manganese, electroflotation, size of particles, electrokinetic potential, flocculants, hydroxides, phosphates, carbonates
Библиографический список

1. Vdovin K. N., Feoktistov N. A., Sinitskiy E. V., Gorlenko D. A., Durov N. A. Melting of high-manganese steel in the electric arc furnace. Technology. Message 1. Izvestiya vysshikh uchebnykh zavedeniy. Chernaya metallurgiya. 2015. Vol. 58. No. 10. pp. 735-739.
2. Soifer V. M. Deoxidation of acidic carbon electric steel by ferromanganese in a ladle. Metallurgiya mashinostroeniya. 2020. No. 5. pp. 2-5.
3. Kolpishon E. Yu., Ivanova M. V., Shitov E. V. Nitrogen-containing steels with equivalent composition. Chernye metally. 2007. No. 2. pp. 10-12.
4. Gorynin I. V., Malyshevskiy V. A., Kalinin G. Yu., Mushnikova S. Yu., Bannykh O. A., Blinov V. M., Kostina M. V. High-strength nitrogen stainless steels. Voprosy materialovedeniya. 2009. No. 3 (59). pp. 7-16.
5. Aleksandrov V. I., Koshel A. A., Yudin V. S. Manganese-zinc elements. Innovatsii v nauke. 2017. No. 4 (65). pp. 62-65.
6. Zaletova N. A. General phosphorus and phosphates of waste waters. Sovremennoe obshchestvo, obrazovanie i nauka. Collection of scientific works of the materials of International scientific-practical conference in 16 parts. 2015. pp. 48-50.
7. Rubanov Yu. K., Tokach Yu. E., Nechaev A. F., Ognev M. N. The galvanic productions waste waters and sludges processing with the heavy metals ions extraction. European Journal of Natural History. 2009. No. 6. pp. 79-80.
8. Beloglazov I. N., Zyryanova O. V., Saltykova S. N. Processing of manganese-containing raw materials with obtaining of high-quality products. Zapiski Gornogo instituta. 2013. Vol. 202. pp. 273-277.
9. SanPiN 1.2.3685-21. Hygienic regulations and requirements to provision of safety and/or harmlessness of environment factors for a human being. 1143 p.
10. Water Framework Directive (WFD) 2000/60/EC: Directive 2000/60/EC of the European Parliament and of the Council of 23 October 2000 establishing a framework for Community action in the field of water policy. 73 p.
11. Mohtashami R., Shang J. Q. Electroflotation for Treatment of Industrial Wastewaters: A Focused Review. Environmental Processes. 2019. Vol. 6. pp. 325-353.
12. Kuokkanen V., Toivo K., Rämö J., Lassi U. Recent Applications of Electrocoagulation in Treatment of Water and Wastewater - A Review. Green and Sustainable Chemistry. 2013. No. 3. pp. 89-121.
13. Kolesnikov V. A., Ilyin V. I., Kapustin Yu. I. et al. Electroflotation technology for purification of waste waters at industrial works. Moscow: Khimiya. 2007. 304 p.
14. Chanturia V. A., Shadrunova I. V., Medyanik N. L., Mishurina O. A. Electric flotation extraction of manganese from hydromineral wastes at yellow copper deposits in the South Ural. Journal of Mining Science. 2010. Vol. 46. No. 3. pp. 311-316.
15. Brodskiy V. A., Zhukov D. Yu., Malkova Yu. O., Kolesnikov V. A. The pH and medium composition impact on the efficiency of electroflotation-based extraction of slightly soluble iron, chromium and manganese compounds from water solutions and physical-chemical properties of these compounds. CIS Iron and Steel Review. 2021. Vol. 21. pp. 75-81.
16. Bolto B., Gregory J. Organic polyelectrolytes in water treatment. Water Resources. 2007. Vol. 41 (11). pp. 2301-2324.
17. Pauling L. General Chemistry. 3th Edition. Dover Publications. 1988. 992 p.
18. Takeno N. Atlas of Eh-pH diagrams. Intercomparison of thermodynamic databases. National Institute of Advanced Industrial Science and Technology Research Center for Deep Geological Environments. 2005. May. 285 p.
19. Brodskiy V., Malkova Yu., Kolesnikov V., Gaidukova A., Perfilieva A. Influence of the preciptator ion on the efficiency of non-ferrous metal ions extraction from aqueous solutions through electroflotation. 19th international multidisciplinary scientific geoconference SGEM 2019. Sophia. 2019. pp.391-398.
20. López-Maldonado E. A., Oropeza-Guzman M. T., Jurado-Baizaval J. L., Ochoa-Terán A. Coagulation–flocculation mechanisms in wastewater treatment plants through zeta potential measurements. Journal of Hazardous Materials. 2014. Vol. 279. pp. 1-10.
21. Wakatsuki T., Furukawa H., Kawaguchi K. Specific and non-specific adsorption of inorganic ions I. Evaluation of specific adsorbability by means of minimum concentration for specific adsorption. Soil Sci. Plant Nutr. 1974. Vol. 20. pp. 353-362.
22. Tzoupanos N. D., Zouboulis A. I. Coagulation–flocculation processes in water/wastewater treatment: the application of new generation of chemical reagents. 6th IASME/WSEAS international conference on heat transfer, thermal engineering and environment (HTE'08). 2008. pp. 309-317.
23. Bratby J. Coagulation and Flocculation in Water and wastewater Treatment. IWA Publishing, London, Seattle. 2006. 583 p.
24. Brodskiy V. A. Role of surface parameters of disersed phase and medium composition in intensification of electroflotation process for purification of waste waters. Dissertation… of a Candidate of Chemical Sciences. Moscpw. 2012. 195 p.
25. Brodskiy V. A., Kolesnikov V. A., Nepochatov V. M., Titov A. L., Kandelaki G. I. Role of intra-phase appearances in extraction of manganese compounds from liquid man-caused wastes. Khimicheskaya promyshlennost segodnya. 2012. No. 2. pp. 34-42.
26. Kumok V. N., Kuleshova O. M., Karabin L. A. Solubility products. Novosibirsk. Nauka. 1983. 267 p.
27. Mishurina O. A. Technology of electroflotation manganese extraction in complex processing of hydro-man-caused georesources of copperpyrite deposits. Dissertation… of a Candidate of Technical Sciences. Nosov Magnitogorsk State Technical University. 2010. 151 p.
28. Alam R., Shang J. Q., Khan A. H. Bubble size distribution in a laboratory-scale electroflotation study. Environ. Monit. Assess. 2017. pp. 189-193.
29. Nazarova G. N., Kostina L. A., Ponurova N. V. On the problem of the mechanism for interaction between metal-bearing deposits with gas bubbles in electrolytic flotation. Collection “Physical and chemical methods of efficiency rise for the processes of mineral raw materials processing”. Moscow. 1973. 116 p.

Полный текст статьи Increase of efficiency of electroflotation extraction of low-soluble manganese compounds from water solutions in presence of flocculants of anion, cation and non-ion types