Журналы →  Eurasian Mining →  2023 →  №1 →  Назад

Название Mixed-type geotechnologies are the basis for cost-effective, safe and ecologically balanced development of ore deposits
DOI 10.17580/em.2023.01.08
Автор Bitimbayev M. Zh., Yusupov H. A., Jumabaev E. I., Fedotenko N. A.
Информация об авторе

National Engineering Academy of the Republic of Kazakhstan, Almaty, Republic of Kazakhstan:

Bitimbayev M. Zh., Professor, Doctor of Engineering Sciences

Jumabaev E. I., Candidate of Engineering Sciences


Satbayev University, Almaty, Republic of Kazakhstan:
Yusupov H. A., Professor, Corresponding Member, Doctor of Engineering Sciences, yusupov_kh@mail.ru


Research Institute of Comprehensive Exploitation of Mineral Resources—IPKON, Moscow Russia:
Fedotenko N. A., Candidate of Engineering Sciences


The steady demand for mineral raw materials requires constant advanced reproduction of the mineral resources. One of the practical solutions to improve the technical and economic indicators of the use of mineral resources is the mixed-type geotechnologies, which in the current situation are created and applied as a special part of mining sciences with many options in relation to mineral deposits and manmade mineral-bearing waste. The review and analysis of the created and proposed geotechnologies allows distinguishing and classifying them with respect to the methods of mining advance and their correlation, and with respect to technologies of mineral recovery from ore mass. Considering mixed-type geotechnologies as a part of the “system of knowledge about the laws of manmade transformation of the Earth’s interior toward new understanding of management and preservation of mineral wealth as a life-support resource for social development” [1], we must move in our reasoning from the general to the particular. The article describes the principles of classification and systematization of mixed-type geotechnologies that ensure selection and achievement of the most efficient and safe method for obtaining final products from minerals.

This study was supported by the Committee of Science of the Ministry of Science and Higher Education the Republic of Kazakhstan, Grant No. AP14871011.

Ключевые слова Mineral mining, mixed-type geotechnologies, hybrid mining method, physicotechnical and physicochemical geotechnologies, economic and ecological efficiency, safety
Библиографический список

1. Trubetskoy K. N., Kaplunov D. R. Mining: Glossary. Moscow : Gornaya kniga, 2016. 635 p.
2. Trubetskoy K. N., Galchenko Yu. P. Elements of mining. Moscow : Akademicheskiy proekt, 2010. 231 p.
3. Morton J. Mine Planning Software Empowers Grade Controllers. Engineering and Mining Journal. 2017. February. pp. 28–33.
4. Oryngozhin Y. S., Yeremin N. A., Metaxa G. P., Alisheva Zh. N. Underground uranium borehole leaching. News of the National Academy of Sciences of the Republic of Kazakhstan–Series of Geology and Technical Sciences. 2020. Vol. 4, No. 442. pp. 62–69.
5. Fathi B., Ashena M., Bahari A. R. Energy, environmental, and economic efficiency in fossil fuel exporting countries: A modified data envelopment analysis approach. Sustainable Production and Consumption. 2021. Vol. 26. pp. 588–596.
6. Yakovlev V. L., Sokolov I. V., Sakantsev G. G., Kravchuk I. L. Transition processes in hybrid mineral mining. Gornyi Zhurnal. 2017. No. 7. pp. 46–50.
7. Kaplunov D. R., Rylnikova M. V., Radchenko D. N. Conditions of sustainable development of Russian mineral industry. GIAB. 2014. pp. 3–11.
8. Trubetskoy K. N., Kaplunov D. R., Rylnikova M. V. Problems and prospects in the resource-saving and resource-reproducing geotechnology development for comprehensive mineral wealth development. Journal of Mining Science. 2012. Vol. 48, No. 4. pp. 688–693.
9. Agoshkov M. I. Classification of mining sciences. Actual problems of development of deposits and use of mineral raw materials. Moscow : MGTU, 1993. pp. 23–30.
10. Antipin Y. G., Baranovsky K. V., Rozhkov A. A., Klyuyev M. V. Overview of combined underground mining systems for ore deposits. Problemy nedropolsovaniya. 2020. No. 3(26). pp. 5–22.

11. Trubetskoy K. N., Malyshev Yu. N., Puchkov L. A. Mining sciences. Development and preservation of the Earth’s interior. Moscow : Akademiya gornyh nauk, 1997. 477. p.
12. Shen N., Li J., Guo Y., Li X. Thermodynamic modeling of in situ leaching of sandstone-type uranium minerals. Journal of Chemical & Engineering. 2020. Vol. 65, Iss. 4. pp. 2017–2031.
13. Ben-Awuah E., Richter O., Elkington T., Pourrahimian Y. Strategic mining options optimization: Open pit mining, underground mining or both. International Journal of Mining Science and Technology. 2016. Vol. 26, Iss. 6. pp. 1065–1071.
14. Wang N., Wan B. H., Zang P., Du X. L. Analysis of deformation development of open-pit slope under the influence of underground mining. Legislation. Technology and Practice of Mine Land Reclamation: Proceedings of the Beijing International Symposium of Land Reclamation and Ecological Restoration. 2015. pp. 53–58. DOI: 10.1201/b17500–11
15. King B., Goycoolea M., Newman A. Optimizing the open pit-to-underground mining transition. European Journal of Operational Research. 2017. Vol. 257, Iss 1. pp. 297–309.
16. Bitimbaev M. Zh. Classification of mixed-type mining methods is the critical factor in integrated mineral field development. Gornyy zhurnal Kazakhstana. 2019. No. 11. pp. 8–13.
17. Bitimbaev M. Zh., Rysbekov K. B., Krupnik L. A., Stolpovskih I. N. Bottom-up ore cutting method. Patent RK. No. 6903. 2022.
18. Bitimbaev M. Zh., Morozov Yu. P., Apakashev R. A. et al. Electrolyzer. Patent RF, No. 2775983. Applied: 03.12.2021. Published: 12.07.2022. Bulletin No. 20.
19. Sokolov I. V., Antipin Yu. G., Nikitin I. V. Basic principles and assessment criteria of technological strategy for underground mining in transition zones. GIAB. 2017. No. 9. pp. 151–160.
20. Shevchenko A. S., Evgrafova E. L., Bitimbaev M. Zh. Investigation of electrochemical chlorination of gold ore of Akgal deposit. Scientific Foundations and Practice of Processing Ores and Man-Made Raw Materials. Conference Proceedings. Yekaterinburg. 2018. pp. 325–330.
21. Aben E. Kh., Rustemov S. T., Bakhmagambetova G. B., Akhmetkhanov D. Enhancement of metal recovery by activation of leaching solution. GIAB. 2019. No. 12. pp. 169–179.
22. Chanturia V. A., Shadrunova I. V., Gorlova O. E., Kolodizhnaya E. V. Development of technological innovations of deep and complex processing of technogenic raw materials in the conditions of new economic challenges. Izvestija Tulskogo gosudarstvennogo universiteta. Nauki o Zemle. 2020. No. 1. рр. 159–171.

Полный текст статьи Mixed-type geotechnologies are the basis for cost-effective, safe and ecologically balanced development of ore deposits